Author Topic: Hilux Recall on teh cards?  (Read 1993 times)

0 Members and 1 Guest are viewing this topic.

Offline Bird

  • Once Was Lost, now am found
  • Hard Top Camper User
  • ******
  • Posts: I am a geek!!
  • Thanked: 1818 times
  • Gender: Male
  • Life is far too long....
    • My Place.
Hilux Recall on teh cards?
« on: August 10, 2018, 10:06:26 AM »
Anyone suffered yet?

Quote
Toyota has not ruled out recalling or replacing faulty air intakes of more than 170,000 Hilux, Fortuner and Prado off-roaders that can leave cars with significantly reduced power and without some active safety systems.

An extensive investigation is currently under way to learn more about the issue that can lead to dust getting past the air filter and into the mass airflow sensor (MAF), in turn disabling the stability and traction control systems – also dropping engine power and urging owners to visit a dealer - something vice president of national operations Sean Hanley says could lead to a permanent fix or recall of affected vehicles.

“We’re looking at it, we’re reviewing it again now, to make sure that we’ve covered every possible angle, that there’s no inherent risk to our customers,” says Hanley. “If we do believe that inherent risk exists you can be one-thousand percent certain we will act as quickly as possible to rectify it.”

The concession and ongoing evaluation appears to be a softening of the stance last month when Toyota said it had no plans to recall or repair affected cars.

However, the brand that dominates the off-road segment with cars marketed as “unbreakable” and better suited to rough Australian roads than any other says there are currently no plans to do more than warn customers of the potential issue and clean the air intakes of vehicles that have been driven in dusty conditions.

Despite disabling key safety software, Toyota is confident there is no safety concern to Prados, Hiluxes and Fortuners fitted with the latest 2.8-litre four-cylinder diesel.

“If we think and believe there’s any risk we would initiate an immediate recall,” Hanley says, adding safety is “an absolute priority”.

“We’re going through that process, at this stage we have no plan to recall.”

Hanley points to internal data that suggests only 0.2 percent of the 170,000-plus cars have so far experienced the fault.

And, he says, of the 340-odd cars that have been reported to dealerships, most are with mining fleets that drive them in “extreme conditions” with a lot of dust.

“We’re looking at every aspect to determine our future actions but at this stage because of the low incidence and extreme driving it’s not warranting a safety recall,” he says. “We’ll continue to assess that.”

However, any fix to new cars is at least a year away, slotting into the annual scheduled technical updates introduced by the brand, the next of which is due around August 2019.

Toyota Australia’s technical team is currently liaising with engineers in Japan regarding a potential fix, something likely to involve the redesign of the air intake system.

When the fix is implemented on new cars, Toyota says it will evaluate cars “on a case-by-case basis” as to whether the new components will be retrofitted to existing cars.

Owners who regularly drive their cars in very dusty conditions, for example, may have their cars’ air intakes replaced at no cost.

Toyota also said it was open to replacing the intakes of owners planning to drive in dusty conditions.

https://www.drive.com.au/motor-news/toyota-reconsidering-hilux-fault-fix-119136.html
-
Click to enlarge

Gone to a new home

Offline Foo

  • Hard Top Camper User
  • ******
  • Posts: 2276
  • Thanked: 181 times
  • Gender: Male
Re: Hilux Recall on teh cards?
« Reply #1 on: August 10, 2018, 01:09:18 PM »
Oh what a feeling. 😃

Foo

Hurry up corkhead!

So long as you have tried your best, you should have no regrets.

Offline Cruiser 105Tvan

  • Hard Top Camper User
  • ******
  • Posts: 2239
  • Thanked: 145 times
  • Gender: Male
  • Another Tvan owner.
Re: Hilux Recall on teh cards?
« Reply #2 on: August 10, 2018, 01:29:18 PM »
Sounds like a lot of ducking and diving and spin/double talk from that Toyota Representative.
Any one else think he should be a Politician?
Robert. 
VK3PPC, VZU641.
2000 FZJ105r bars,
HDJ105r Bars F&R, VRS Winch, ATZ. P3's, a cupla 2 ways as well.
and 2009 Canning Tvan pushing.

Offline 4runnernomore

  • Soft Floor Camper User
  • ****
  • Posts: 695
  • Thanked: 17 times
  • Gender: Male
Re: Hilux Recall on teh cards?
« Reply #3 on: August 12, 2018, 12:43:08 PM »
Interesting to see what Toyota does when owners of these vehicle submit claims against them for replacement motors due to their motors been dusted in the next few years.

Cheers, Chris

Offline Bird

  • Once Was Lost, now am found
  • Hard Top Camper User
  • ******
  • Posts: I am a geek!!
  • Thanked: 1818 times
  • Gender: Male
  • Life is far too long....
    • My Place.
Re: Hilux Recall on teh cards?
« Reply #4 on: August 12, 2018, 01:34:59 PM »
Quote from: 4runnernomore
Interesting to see what Toyota does when owners of these vehicle submit claims against them for replacement motors due to their motors been dusted in the next few years.

if its like nissan did with the poor bastards and their ZD30's - they'll hand em a bill.
-
Click to enlarge

Gone to a new home

Offline banksy69

  • Swag User
  • **
  • Posts: 53
  • Thanked: 6 times
Re: Hilux Recall on teh cards?
« Reply #5 on: August 12, 2018, 08:16:21 PM »
Hire car just out of Port headland, went to overtake a quad (truck with 4 trailers) half way past and the car went limp mode.
Car went to 3rd gear, doing 110.
If toyota thinks its not a recall they will have blood on their hands.

Offline Moxley

  • Tent User
  • ***
  • Posts: 203
  • Thanked: 12 times
Re: Hilux Recall on teh cards?
« Reply #6 on: August 12, 2018, 09:58:01 PM »
Hire car just out of Port headland, went to overtake a quad (truck with 4 trailers) half way past and the car went limp mode.
Car went to 3rd gear, doing 110.
If toyota thinks its not a recall they will have blood on their hands.

That would have been horrible. I wonder if Toyota sales will go down. It would be amazing if they didn’t.

Offline gronk

  • KKK... Kwik Kool Kamping
  • Hard Top Camper User
  • ******
  • Posts: 7996
  • Thanked: 401 times
  • Gender: Male
Re: Hilux Recall on teh cards?
« Reply #7 on: August 12, 2018, 10:18:43 PM »
The 200 series has had the same dust issues for 10 + yrs, but no maf sensor issues so no worries for Toyota !!
2009 200 series Yota
2019 Lifestyle Ultra