Author Topic: "Prepping" Canvas  (Read 3434 times)

0 Members and 1 Guest are viewing this topic.

Offline grant110

  • Sleeping Bag User
  • *
  • Posts: 34
  • Gender: Male
  • New to the camper scene
"Prepping" Canvas
« on: April 29, 2014, 05:17:13 PM »
Hi All - Just bought the new camper.  I have done a bit of a forum search but to no avail.  Is there a preferred method - or need  - to further waterproof or prep canvas?  the camper comes with 14oz ripstop - yes its a chinese tent...  Any thoughts?


Offline Daz100

  • Sleeping Bag User
  • *
  • Posts: 38
  • Thanked: 3 times
  • Gender: Male
  • Yeah... Why Not
Re: "Prepping" Canvas
« Reply #1 on: April 29, 2014, 05:31:41 PM »
G'day Grant

set up the tent - then get the garden hose out and water it down - don't be shy - give it a good soaking, then let it dry off - after this hit it again


after you have wet it down - go inside of it and check for any leaks - water pooling on roof - you may need an extra spreader or two in some areas - depending on size of tent


I done mine two/three times over about two days


this will help close up any holes from stitching



Cheers daz

Offline Banjo16

  • Soft Floor Camper User
  • ****
  • Posts: 684
  • Thanked: 34 times
  • Gender: Male
  • The road less travelled
Re: "Prepping" Canvas
« Reply #2 on: April 29, 2014, 06:46:35 PM »
Did my Chinese 3 times but it's not rip stop.
Cheers,
Don

PB Challenger
Jayco Starcraft OB

Offline ozstickman

  • Soft Floor Camper User
  • ****
  • Posts: 647
  • Thanked: 1 times
  • Gender: Male
  • Just Grinning
Re: "Prepping" Canvas
« Reply #3 on: April 29, 2014, 06:52:53 PM »
I've done the wet n dry heaps of times but thinking of giving it a waterproofing spray as extra protection


Sent from my Ring-a-ding-a-ling
Don't complain! It could be worse, you could be six foot under or a brick of ashes!!
Our camper Barry - http://www.myswag.org/index.php?topic=31963.0

Offline Cruiser 105Tvan

  • Hard Top Camper User
  • ******
  • Posts: 2239
  • Thanked: 145 times
  • Gender: Male
  • Another Tvan owner.
Re: "Prepping" Canvas
« Reply #4 on: April 29, 2014, 07:00:27 PM »
Sounds like you got dudded Tareepato ;D >:D >:D >:D ;D Jus jokin.

Canvas needs to be thoroughly wet and shrunk to seal any imperfections, or needle holes from stitching.
Doesn't matter if ripstop or not.
There are products for sealing seams, most new tents shouldn't need them.
Canvas usually leaks if you allow water to sit and pool on the canvas. 
Causing a droop in the fabric that fills with water, and drips inside the tent.
There is usually a set of care instructions, attached to the tent or, with the tent when  purchased.
Robert. 
VK3PPC, VZU641.
2000 FZJ105r bars,
HDJ105r Bars F&R, VRS Winch, ATZ. P3's, a cupla 2 ways as well.
and 2009 Canning Tvan pushing.

Offline Bird

  • Once Was Lost, now am found
  • Hard Top Camper User
  • ******
  • Posts: I am a geek!!
  • Thanked: 1818 times
  • Gender: Male
  • Life is far too long....
    • My Place.
Re: "Prepping" Canvas
« Reply #5 on: April 30, 2014, 09:48:59 AM »
Search for "seasoning canvas"
-
Click to enlarge

Gone to a new home

KingBilly

  • Guest
Re: "Prepping" Canvas
« Reply #6 on: April 30, 2014, 10:17:30 AM »
Canvas needs to be thoroughly wet and shrunk to seal any imperfections, or needle holes from stitching.

Agree, the whole idea of seasoning canvas is to get the cotton to shrink and close the needle holes in the seams.  May need to wet and dry a few times.  Good canvas will have been treated and should not leak elsewhere.

Doesn't matter if ripstop or not.

Some of the imported ripstop canvas is a blend of poly and cotton.  The poly will not shrink hence why they use this combination in clothes.  So seasoning will not be as effective on canvas which contains poly, the higher the poly content the less effective seasoning will be.  In nylon tents, to seal the seams, the manufacturers use a seam seal tape.

KB

Offline Cruiser 105Tvan

  • Hard Top Camper User
  • ******
  • Posts: 2239
  • Thanked: 145 times
  • Gender: Male
  • Another Tvan owner.
Re: "Prepping" Canvas
« Reply #7 on: April 30, 2014, 12:31:41 PM »
That's right, you cannot season nylon or polyester fabrics.
It's the Cotton part of the fabric that needs the treatment.
Cotton absorbs the proofing whereas the plastic type threads get coated.
By shrinking the Cotton, the weave of the fabric is pulled tighter and becomes more waterproof.The cotton swells with the moisture. 
As it dries the fabric pulls itself tighter together.
It's not noticeable, unless you actually measure it. 
It may take some number of wettings, rain showers over time, to make any difference.
« Last Edit: April 30, 2014, 12:57:52 PM by Cruiser 105Tvan »
Robert. 
VK3PPC, VZU641.
2000 FZJ105r bars,
HDJ105r Bars F&R, VRS Winch, ATZ. P3's, a cupla 2 ways as well.
and 2009 Canning Tvan pushing.

Offline Azz

  • Soft Floor Camper User
  • ****
  • Posts: 528
  • Thanked: 39 times
  • Gender: Male
Re: "Prepping" Canvas
« Reply #8 on: April 30, 2014, 12:47:17 PM »
Most of the time Poly / Cotton thread is used, so you are also making the cotton component of the thread swell to fill the hole where the needle has pushed through the fabric.
The needle of course is bigger than the thread, as the thread passes through the needle.

There are very few 100% cotton canvases. Swag canvas is one.
The poly is the fabric dimensional stability and strength. It also last better in the weather than cotton.

Cotton gives the flexibility and a little stretch. Most canvas is 50 / 50 or very close to.

If you have a feel of striped annex walling, it feels stiffer than a plain roofing canvas as most walling is 100% poly.

So as others have said, by wetting your new canvas you are getting the canvas and thread (in most cases) to expand and fill the gap between the canvas & thread.

The humidity can be enough to stop leaks from new. I have had very few new annexes or campers leak in 25 years of making canvas stuff.
The worst I ever had was my own camper, it was like a sieve for the first few trips away.

I am personally not a huge fan of the poly cotton canvas used on campers these days. There are far stronger and lighter fabrics available.
These fabrics also pack much smaller. But like everything in life (and camping) its a compromise.  :D